Preparation, double-checking are key to spring planting safety

April 11, 2013  


WEST LAFAYETTE, Ind. - With sunny days becoming more frequent and soil temperatures rising, a Purdue Extension agricultural safety specialist warns farmers not to let their enthusiasm for spring planting lead to injuries.

Instead, growers need to take a few extra minutes to double-check equipment that has been idle over the winter and keep safety precautions in mind.

"Farmers need to make sure before they go into planting season that the safety guards are in place on their equipment," Steve Wettschurack said. "Maybe a piece was taken off last fall because it was broken or worn out, but now it needs to be replaced. They should make sure they've looked at hydraulic hoses and anything else that might be a yearly repair before heading out to the fields.

"Not cutting corners is important. It only takes a few minutes to make sure a piece of equipment is safe and ready for transport."

Safety equipment such as headlights, taillights, hazard signs, goggles and gloves also should be checked before planting begins.

Most farm equipment has a large width when fully extended, but Wettschurack said farmers moving equipment should always fold it into transport position.

"Some toolbars on planters are 90 feet wide when they're opened up in the field, and we're talking about a roadway that's 12 feet wide," he said. "They're designed to fold themselves up, maybe numerous times, to get down to roadway width."

Planters, discs, field cultivators and other equipment can be folded up hydraulically in a matter of minutes. The equipment should be fully folded between fields - no matter the distance between them - for the safety of the farmer and other drivers.

Non-farm drivers also should be extra cautious on the roads during planting season.

"Unfortunately, it seems like we have people in a lot more of a hurry today, and they don't quite want to get over as much as they used to," Wettschurack said. "But give the farmer that courtesy. And the farmer needs to give that individual on the road courtesy to make sure they get by each other safely."

Wettschurack also advised farmers to do general inspections of anhydrous ammonia tanks before using them in the fields. If a tank has a water storage supply on the side, it needs to be full before going out in the field.

Anhydrous ammonia, when spilled, can cause severe burns to eyes, lungs and skin. Because it is attracted to water, the best way to minimize injury after a spill is to douse the victim with water.

"Copious amounts of water is the No. 1 thing to do pre-hospital if you get a drop of anhydrous on you. The more water the better," Wettschurack said.

He cautioned farmers to keep the wind at their backs when applying anhydrous ammonia to avoid exposure. If the wind is from the south, farmers need to keep equipment north of them so the anhydrous is blowing away.

Farmers should also check gauges, tires and wheel bearings for signs of distress or rust.

"A tire blowing out when going 30 miles an hour down the road can cause a lot of damage," Wettschurack said.

Writer: Amanda Gee, 765-494-8402, agee@purdue.edu

Source: Steve Wettschurack, 765-714-4557, swettsch@purdue.edu

Ag Communications: (765) 494-2722;
Keith Robinson, robins89@purdue.edu
Agriculture News Page

Faculty-Staff News

More News

Purdue University, 610 Purdue Mall, West Lafayette, IN 47907, (765) 494-4600

2014 Purdue University | An equal access/equal opportunity university | Copyright Complaints | Maintained by Marketing and Media

If you have trouble accessing this page because of a disability, please contact Purdue Marketing and Media at online@purdue.edu.