U.S. does not have infrastructure to consume more ethanol

January 4, 2011

Wally Tyner says it will take advances in next-generation biofuels for the United States to meet federal Renewable Fuel Standard requirements. (Purdue Agricultural Communication photo/Tom Campbell)

Download image

WEST LAFAYETTE, Ind. - The United States doesn't have the infrastructure to meet the federal mandate for renewable fuel use with ethanol but could meet the standard with significant increases in cellulosic and next-generation biofuels, according to a Purdue University study.

Wally Tyner, the James and Lois Ackerman Professor of Agricultural Economics, and co-authors Frank Dooley, a Purdue professor of agricultural economics, and Daniela Viteri, a former Purdue graduate student, used U.S. Department of Energy and Environmental Protection Agency data to determine that the United States is at the "blending wall," the saturation point for ethanol use. Without new technology or a significant increase in infrastructure, Tyner predicts that the country will not be able to consume more ethanol than is being currently produced.

The federal Renewable Fuel Standard requires an increase of renewable fuel production to 36 billion gallons per year by 2022. About 13 billion gallons of renewable fuel was required for 2010, the same amount Tyner predicts is the threshold for U.S. infrastructure and consumption ability.

"You can't get there with ethanol," said Tyner, whose findings were published in the December issue of the American Journal of Agricultural Economics.

Tyner said there simply aren't enough flex-fuel vehicles, which use an 85 percent ethanol blend, or E85 stations to distribute more biofuels. According to EPA estimates, flex-fuel vehicles make up 7.3 million of the 240 million vehicles on the nation's roads. Of those, about 3 million of flex-fuel vehicle owners aren't even aware they can use E85 fuel.

There are only about 2,000 E85 fuel pumps in the United States, and it took more than 20 years to install them.

"Even if you could produce a whole bunch of E85, there is no way to distribute it," Tyner said. "We would need to install about 2,000 pumps per year through 2022 to do it. You're not going to go from 100 per year to 2,000 per year overnight. It's just not going to happen."

And even if the fuel could be distributed, E85 would have to be substantially cheaper than gasoline to entice consumers to use it because E85 gets lower mileage, Tyner said. If gasoline were $3 per gallon, E85 would have to be $2.34 per gallon to break even on mileage.

There is talk of increasing the maximum amount of ethanol that can be blended with gasoline for regular vehicles from 10 percent to 15 percent. But Tyner said that even if the EPA does allow it, the blending wall would be reached again in about four years.

Tyner said advances in the production of thermo-chemical biofuels, which are created by using heat to chemically alter biomass and create fuels, would be necessary to meet the Renewable Fuel Standard. He said those fuels would be similar enough to gasoline to allow unlimited blending and would increase the amount of biofuel that could be used.

"Producing the hydrocarbons directly doesn't have the infrastructure problems of ethanol, and there is no blend wall because you're producing gasoline," Tyner said. "If that comes on and works, then we get there. There is significant potential to produce drop-in hydrocarbons from cellulosic feedstocks."

The U.S. Department of Agriculture funded Tyner's research.

Writer:  Brian Wallheimer, 765-496-2050, bwallhei@purdue.edu

Source:  Wally Tyner, 765-494-0199, wtyner@purdue.edu

Note to Journalists: For a copy of the paper, e-mail Brian Wallheimer at bwallhei@purdue.edu

Ag Communications: (765) 494-2722;
Keith Robinson, robins89@purdue.edu
Agriculture News Page